PUMPER APPARATUS SCHEDULE “B” SERVICE
TASK DESCRIPTION
WALK AROUND/EXTERIOR INSPECTION
______ CAB & BODY EXTERIOR INSPECT OVERALL CONDITION
______ CHECK FLUID LEAKS
______ CHECK AIR LEAKS
______ TIRES/CHECK PRESSURE/WEAR/DAMAGE
______ MUD FLAPS/INSPECT
______ MISSING CAPS, OIL, FUEL/INSPECT
_______ CHECK ELECTRIC HORN/AIR HORN
______ LIGHTS OEM/CHECK OPERATION
______ LIGHTS/PURSUIT/CODE 3/CHECK OPERATION
______ LIGHTS/EMERGENCY/SAFETY/CHECK OPERATION
______ LIGHTS/ALLEY/WORK CHECK OPERATION
______ ALL OTHER LIGHTS NOT LISTED
HARDWARE CHECK
______ CAB INSIDE
______ CAB OUTSIDE
______ BODY, LEFT SIDE
______ BODY, RIGHT SIDE
______ BODY, TOP
______ BODY, REAR
SAFETY EQUIPMENT INSPECTION
______ WHEEL CHOCKS/INSPECT
______ SIGNAGE/INSPECT
IN CAB/TEST DRIVE INSPECTION
______ DOOR LATCHES/HINGES/LOCKS/INSPECT
______ CAB INTERIOR/INSPECT OVERALL CONDITION
______ MIRRORS/CHECK OPERATION
______ WINDSHIELD/WASHER/WIPER/CHECK OPERATION
______ ELECTRIC HORN
______ AIR HORN
______ ALARMS
______ BRAKES/A.B.S./SYSTEM CHECK
______ SEAT BELTS/RESTRAINTS/HARNESS/CHECK
______ STARTER/CRANKING SYSTEM CHECK OPERATION
______ INSTRUMENT PANEL/GAUGES/LIGHTS/BUZZERS/SIGNAL
______ THROTTLE/CHECK OPERATION
______ BRAKES/5 POINT INSPECTION
______ P.T.O./CHECK OPERATION
______ TRANS SHIFT CONTROLS/CHECK OPERATION
______ ROAD TEST/TEST DRIVE
______ A/C & HEATING/CHECK OPERATION
______ ENGINE/JACOBS BRAKE/CHECK OPERATION
______ RETARDER/ELECTRIC/CHECK OPERATION
______ TRANS OUTPUT RETARDER/CHECK OPERATION
______ BRAKE PARKING/CHECK OPERATION
______ LIGHTS/HEADLIGHTS CHECK/ADJUST
PRIMARY ENGINE
______ CAB JACK/CHECK FLUID LEVEL/OPERATION
______ PRESSURE CLEAN ENGINE
______ ENGINE OIL/CHECK/ADD
______ FILTER AIR/REPLACE
______ CRANKCASE BREATHER TUBES/INSPECT
______ THROTTLE LINKAGE/CHECK OPERATION/LUBE
______ ENGINE THROTTLE/CHECK FULL FUEL POSITIONING
______ ENGINE/CHECK/ADJUST SHUT DOWN MECHANISM
______ COMPRESSOR FILTER/CHECK/CHANGE
______ WASHER WINDSHIELD/CHECK/FILL/RESERVOIR
______ TURBO CHARGER CONNECTION/INSPECT
______ ENGINE/DRIVE BELTS/CHECK WEAR/ADJUST
______ STEERING MITER BOX/CHECK FLUID LEVEL
______ POWER STEERING FILTER/REPLACE
______ POWER STEERING FLUID – REPLACE IF NECESSARY
______ POWER STEERING PUMP/CHECK FLUID
______ FUEL SYSTEM/CHECK TANK CONTAMINATION
______ FUEL FILTER/REPLACE
______ WATER FILTER/SEPARATOR/REPLACE
______ BATTERY CABLES/CHECK/CLEAN
______ BATTERY/TEST AND SERVICE
______ CHARGING SYSTEM/CHECK
______ VOLTAGE REGULATOR/CHECK
______ ALTERNATOR/CHECK OUT PUT
______ COOLING SYSTEM WATER PUMP/CHECK
______ COOLING SYSTEM FAN/CLUTCH/CHECK
______ RADIATOR/MOUNTS/INSPECT
______ COOLING SYSTEM HOSES/CHECK
______ RADIATOR/CAP/CHECK
______ COOLING SYSTEM/PRESSURE CHECK
______ COOLING SYSTEM/LITMUS TEST
______ COOLANT DRAIN/REPLACE
______ COOLING SYSTEM/FILTER REPLACE
______ COOLANT CHECK/ADD
______ TRANS FLUID/CHECK LEVEL
______ ENGINE COVER BOLTS/CHECK/TIGHTEN
UNDER VEHICLE
______ ENGINE/CHANGE OIL/FILTER/SAMPLE
______ COOLING SYSTEM/FREEZE PLUGS/CHECK
______ KING PINS/BALL JOINTS/CHECK FOR WEAR
______ LUBRICATE KING PINS/BALL JOINTS
______ TIE ROD/DRAG LINK/PITMAN ARM/CHECK PLAY
______ LUBRICATE TIE ROD/DRAG LINK/PITMAN ARM
______ STEERING GEAR/LINKAGE/CHECK FOR PLAY
______ SUSPENSION/CHECK PINS/BUSHINGS/LUBRICATE
______ FRONT END ALIGNMENT/CHECK
______ RETARDER/ELECTRIC/LUBE
______ U-JOINT/FLANGES/CHECK
______ PTO DRIVELINE/U-JOINTS CHECK
______ PTO DRIVELINE/U-JOINTS LUBE
______ LUBE U-JOINT/FLANGES
______ PUMP (FIRE) TRANS/LUBE OUTBOARD/3RD STAGE BRG
______ SUSPENSION/CHECK SPRINGS/SHACKLES/SHOCKS
______ POWER STEERING/INSPECT LINES/HOSES/FITTINGS
______ SUSPENSION/CHECK TORQUE ON U-BOLTS
______ EXHAUST SYSTEM/INSPECT
______ AIR BOX DRAINS/INSPECT
______ ENGINE OIL COOLER LINES/INSPECT FOR LEAKS
______ FUEL PUMP/INSPECT
______ FUEL SYSTEM/CHECK LINES/MOUNTING
______ ENGINE MOUNTS/INSPECT
______ PUMP (FIRE) TRANS/CHECK/DRIVELINE/U-JOINTS
______ LUBE PUMP/TRANS/U-JOINTS
______ DIFFERENTIAL/CHECK FLUID LEVEL/CLEAN VENTS
______ DIFFERENTIAL/CHANGE FLUID
______ CAB & BODY/MOUNTS/CRACKS/HARDWARE/INSPECT
______ AIR SYSTEM/CHECK LINES/HOSES/FITTINGS
______ FUEL SYSTEM TANK DRAIN/CHECK
______ FRAME AND SUPPORTS CHECK FOR CRACKS
______ TRANS/CHANGE OIL/FILTERS/CHECK FOR LEAKS
______ TRANS/CHECK MOUNTS/LINES/FITTINGS
______ TRANS/CHECK LINKAGE
______ PUMP (FIRE) TRANS/CHECK FLUID LEVEL/LEAKS
______ GEAR BOXES/CHECK FLUID LEVEL
______ PUMP (FIRE) TRANS/CLEAN OIL PUMP STRAINER
______ BRAKES/AIR TANK/DRAIN
______ HUBS/CHECK OIL LEVEL
______ STUDS/THREADS/LUG NUTS/CHECK
______ WHEELS/INSPECT FOR CRACKS
______ BRAKES/INSPECT SHOES/PADS/WEAR
______ BRAKES/INSPECT LINES/HOSES/WHEEL CYLINDERS
______ WHEEL BEARINGS/SEALS/REPACK/REPLACE
______ BRAKES/CHECK/ SLACK ADJUSTERS
______ BRAKES/AIR DRYER/SERVICE
______ ADJUST BRAKES
MOUNTED EQUIPMENT
______ PUMP (FIRE) PRIMING TANK/CHECK LEVEL
______ PUMP PRIMER MOTOR/CHECK
______ PUMP (FIRE) DRY VACUUM TEST/PRESURE TEST
______ PUMP VALVES/SUCTION/DISCHARGE/CHECK
______ PUMP (FIRE) SHIFT UNIT/CHECK
______ PUMP (FIRE) PANEL THROTTLE/CHECK OPERATION
______ PUMP (FIRE) CHECK PACKING FOR LEAKAGE/ADJUST
______ PUMP (FIRE) CHECK DISCHARGE DRAINS
______ PUMP (FIRE) CHECK PUMP OPERATION
______ PUMP (FIRE) TRANSFER VALVE/CHECK/POSITIONS/LUBE
______ PUMP (FIRE) PRESSURE GOVERNOR/CHECK OPERATION
______ PUMP (FIRE) PRESS RELIEF VALVE/CHECK OPERATION
______ PUMP (FIRE) FOAM/CHECK OPERATION/MIXING PERCENT
______ PUMP PRIMING (FIRE) PILOT VALVE/CLEAN SCREEN
______ PUMP (FIRE) CHANGE OIL
______ PIVOTS/PINS/CHECK/LUBE
______ CHAINS/SPROCKETS/LUBE/ADJUST
______ CABLES/LUBE/ADJUST
______ HOSE REEL/CHECK OPERATION
______ ALL WEAR POINTS/CHECK
BREATHING AIR SYSTEM
______ COMPRESSOR TANK DRAINS/CHECK
______ COMPRESSOR VALVES/CONTROLS/CHECK
______ COMPRESSOR AIR FILTER/REPLACE
SERVICE GENERATOR
_______ CHANGE OIL AND FILTER
_______ CHANGE FUEL FILTER
_______ CHANGE COOLANT
_______ CLEAN OR REPLACE AIR CLEANER